Moves by major U.S. fast-food chains to temporarily pull fresh onions off their menus on Thursday, after the vegetable was named as the likely source of an E. coli outbreak at McDonald’s, laid bare the recurring nightmare for restaurants: Produce is a bigger problem for restaurants to keep free of contamination than beef.
Onions are likely the culprit in the McDonald’s E. coli outbreak across the U.S. Midwest and some western states that has sickened 75, up from 49, and killed one. The world’s largest burger chain temporarily paused serving the Quarter Pounder in a fifth of its 14,000 U.S. restaurants that were impacted, the company had said on Wednesday.
Of the 61 people for whom information was available, 22 were hospitalized, and two developed hemolytic uremic syndrome, a serious condition that can cause kidney failure, the U.S. Food and Drug Administration (FDA) said on Friday.
In past years, beef patties dominated the dockets of lawyers dealing with food-borne illness cases, before U.S. federal health regulators cracked down on beef contamination after an E. coli outbreak linked to Jack in the Box burgers hospitalized more than 170 people across the country and killed four. As a result, beef-related outbreaks became much rarer, experts say.
“Produce is a much harder problem,” said Mike Taylor, a lawyer who played leadership roles in safety efforts at the FDA and the U.S. Department of Agriculture, and is now on the board of a non-profit called STOP Foodborne Illness.
Experts say the biggest difference is that beef is cooked while fresh produce, by definition, is not. Proper cooking is a “silver bullet” against contamination, said Donald Schaffner, a Rutgers University food science and safety expert.
Large-scale industrial produce is washed, sanitized and tested to a similar degree that beef is, but tests cannot catch sufficiently low levels of contamination, experts say.
Crops are often grown outdoors, where feces from wildlife or nearby agricultural animals can seep into irrigation water or floodwater. E. coli is a normal pathogen in the guts of animals. Cattle have it more than others, but it has also been detected in geese, boars, deer and others, said Mansour Samadpour, a food safety specialist.
Contamination could arise from using untreated manure or contaminated irrigation water, or from holding or slicing the onions in a way that they became contaminated, Schaffner said.
Samadpour, who is chief executive of IEH Laboratories and Consulting Group, and was hired by Chipotle to overhaul its food safety regime after a series of contamination episodes in the mid-2010s, said U.S. Department of Agriculture officials insisted on stronger testing of beef. “We went from one or two beef recalls a month to one recall every year or three,” he said.
Similar rigorous testing is applied to produce, and fast-food chains and other buyers often require it. But tests do not detect everything. The cleaner the product, the harder it is to detect, Samadpour said.
Tougher regulations
Both McDonald’s and Taylor Farms, a supplier of yellow onions to McDonald’s in the affected states, are large and sophisticated companies, widely regarded by food safety experts as standard-bearers for safe practices.
McDonald’s suppliers test produce frequently and did so in the date range given by the U.S. Centers for Disease Control and Prevention (CDC) for the outbreak, and none of them identified this E. coli strain, company spokespeople said.
Wendy’s pulled lettuce from restaurants in several states in 2022 after the CDC suspected it was the source of an E. coli outbreak that sickened dozens.
In 2006, lettuce from Taco Bell was identified as the likely source of an E. coli outbreak that sickened 71 people. Taco Bell is currently owned by Yum Brands. Contamination can extend even beyond pathogens such as E. coli and salmonella. McDonald’s previously dealt with a parasitic outbreak in 2018 linked to salads that sickened nearly 400.
The U.S. Food Safety Modernization Act of 2011 required the FDA to establish standards for the safe production and harvesting of fruits and vegetables. The FDA introduced regulations for farm produce that previously was not subject to much regulation, Rutgers’ Schaffner said.
“Very often the pattern is we have a public health problem or a food safety problem, and eventually Congress will react and we’ll have regulations,” he said.
When there’s a salmonella outbreak, scientists do genetic sequencing on bacteria samples from infected patients and bacteria of the contaminated food product. If there is a match, it can help determine the source of the foodborne illness. Correction: A previous title on the video suggested that the B.C. Centre for Disease Control lab discovered the salmonella outbreak linked to cantaloupe. In fact, the BCCDC was part of a number of labs to track the outbreak.
Taylor, the former FDA official, said that while beef contamination was more or less solved through government regulation, improving the safety of produce is best left to buyers, such as McDonald’s and other fast-food chains.
He said he believes that fast-food chains and grocery stores, as major buyers of produce, can collectively “modernize and harmonize” the standards they expect from suppliers. The produce marketplace is fragmented and diverse.
“The only thing that could for sure destroy the microbes is radiation — but no one wants it,” food-safety expert Samadpour said, adding it is impractical due to the volumes of produce that are sold. In addition, for many people radiation carries an “ick factor” when applied to food, he said.
